To determine spacing required for a load of pallets weighing 3,000 pounds each, perform this computation: 3,000 divided by 45.2 equals 66 inches center to center. OCONUS, turn in reparable pallets IAW TO 35D Do not ship nets on pallets to the depot repair facility. But determining which functions may be performed by contractors and, Template modified: 27 May 1997 14:30 BY ORDER OF THE SECRETARY OF THE AIR FORCE AIR FORCE INSTRUCTION 32-4007 7 MARCH 1994 Civil Engineering CAMOUFLAGE, CONCEALMENT, AND DECEPTION COMPLIANCE WITH THIS, Terms and Conditions for Purchase Orders for Recycling Materials This Agreement is made by and between AEROJET-GENERAL CORPORATION, an Ohio corporation with a place of business at Rancho Cordova, California, Department of Defense INSTRUCTION NUMBER 5010.40 May 30, 2013 USD(C)/CFO SUBJECT: Managers Internal Control Program Procedures References: See Enclosure 1 1. (Each axle of a vehicle must be computed separately.). (2) A set of large 463L pallet nets has a maximum capacity of 10,000 pounds at 8 Gs when properly installed. There is no requirement to use a barrier system. 03-01 Effective: July 25, 2003 SUBJECT: WAREHOUSE FACILITIES ORDERING, RECEIVING, SECURING, STORING, AFMAN 23-110, CD BASIC USAF SUPPLY MANUAL 1 April 2009 Incorporating Through Interim Change 11, 1 APRIL 2012 FOREWORD (Summary of Changes) Summary of Changes (AF/A4LM) NEW Inventory Control Matrix AFILSEPL. SHORING. b. Never put more than 50 percent of the tie-downs on axles of wheeled equipment. Use at least two spacers between the pallets being married; use more if necessary. Identify the, Department of Defense INSTRUCTION NUMBER 4151.19 January 9, 2014 USD(AT&L) SUBJECT: Serialized Item Management (SIM) for Life-Cycle Management of Materiel References: See Enclosure 1 1. Shortfalls must include an itemized (inventory) justification showing valid need for retaining assets. It is then easier to secure the cargo to the pallet. 18-4. Develop, obtain approval for, publish, update, and distribute supplements to this regulation. Cargo Nets. When securing cargo to the pallet, the following procedures apply. (1) The weight of the load resting on shoring is not spread equally over the entire area of contact between the shoring and the surface. Make sure that the tally sheets indicate that the pallet is married. Step 4. DODIG-2015-147 JULY 10, 2015 U.S. Army Contracting Command Rock Island Needs to Improve Contracting Officer s Representative Training and Appointment, DEPARTMENT OF DEFENSE Defense Contract Management Agency INSTRUCTION Small Business Process Contracts Directorate DCMA-INST 119 OPR: DCMA-AQS 1. Properly laid shoring will distribute weight evenly over a large area. c. Using inputs from subordinate organizations, compile and submit reports. After the side nets are attached and adjusted, place the top net over the pallet. i. The loading methods for the CH-47 HICHS are as follows: (1) 463L pallets. SUBJECT: WAREHOUSE FACILITIES ORDERING, RECEIVING, SECURING, STORING, AND DISPENSING MATERIALS. 39C-3. postal agreement with the department of defense, Washington Headquarters Services ADMINISTRATIVE INSTRUCTION, Office of Small and Disadvantage Business Utilization (OSDBU) Logistics Support Contract, DEPARTMENT OF THE NAVY COMMANDER, NAVY INSTALLATIONS COMMAND 716 SICARD STREET, SE, SUITE 1000 WASHINGTON NAVY YARD, DC 20374-5140, UCLA Information Technology Services/ Medical Center Information Technology Services Ronald Reagan UCLA Medical Center, Department of Defense MANUAL. Army Quality Program. This instruction: a. Reissues DoD, To make this website work, we log user data and share it with processors. 39C-1. PURPOSE, Dear Carrier, Thank you for your interest in becoming a carrier for Maverick Logistics, LLC. Field Repair: Field-level repairs are authorized by Technical Order (TO). (b) Triangle. system constrictor cargo 463l pallet d. Units desiring surface transport of System 463L-loaded cargo must request a waiver through their CCMD TAM, Service pallet and net manager, or special programs program manager. 39C-4. c. Units are permitted to palletize cargo for surface movement during inspections/exercises or for special programs. Start with the left ring side of the numbers 26 through 30 (see Figure 18-4). PURPOSE. Lift straps just attached over the corner of the cargo in the same manner as in step 5. Combining the 463L vehicles, pallets, rollers, and rails within the aircraft, can reduce ground time by as much as 75 percent. g. Redistribute assets to reduce significant overages and fill shortages. Control, maintain, and report pallets and nets IAW this regulation, its appendices, supplements, and referenced TOs b. After both side nets are attached, lift strap 31 of both nets over the corner of the cargo on the pallet. The sides of the net with five straps (A through E) are placed on the long side of the pallet. This instruction: a. Reissues DoD, Nominee POC: Joann T. Glasgow Mailing Address: DSCP-IB 700 Robbins Avenue Philadelphia, PA 19111 Joann.Glasgow@dscp.dla.mil Telephone: (Com) 215-737-8310 (DSN) 444-8310 Financial POC: Denise Scott Mailing, United States Government Accountability Office Report to the Subcommittee on Readiness and Management Support, Committee on Armed Services, U.S. Senate July 2014 AIR FORCE WORKING CAPITAL FUND Actions, Audit Report Report Number IT-AR-16-007 June 13, 2016 Software Change Management for Engineering Systems Our objective was to evaluate the effectiveness of the software change management process for Engineering, IUP PURCHASING CARD PROGRAM PROCEDURAL GUIDELINES Updated February, 2016 1. Ensure and verify all subordinate activities are reporting their System 463L assets in GART. The preferred source, GFP and CAP Basics Webinar Script Amber Barber 30 April 2010 WELCOME Thank you all for joining us. 3. Before pallets can be married, personnel must inspect them on the top, bottom, and sides to ensure that they are in good condition. I. Recitals A. (1) Placement of spacers. REISSUANCE AND, UNITED STATES GOVERNMENT Memorandum LIBRARY OF CONGRESS Office of the Inspector General TO: FROM: Jo Ann Jenkins Chief Operating Officer Karl W. Schornagel Inspector General April 15, 2008 SUBJECT: Summary, SECTION 12: VETERANS AFFAIRS NATIONAL CEMETERY ADMINISTRATION MEMORIAL PROGRAM CEMETERY MONUMENTS (SUPPLEMENTAL TL RATES) ROUTE ORDER SUBMISSION 2 12-1. Good supervision ensures that adequate care is taken in handling and storing pallets and nets. Prepare, mark, and label reparable pallets to be consigned to the depot repair facility IAW TO 35D Prepare and ship nets to the depot IAW TO 35D a. Pallets. HQ Air Mobility Command (AMC/A4T) is the DOD Operational Manager and provides direction for worldwide DOD System 463L asset management. Sec. Do not ship nets on System 463L pallets to the depot repair facility. SECTION XI - INVENTORY / FIXED ASSETS FIXED ASSETS PROCEDURES WHO IS RESPONSIBLE? Step 13. System 463L assets supporting sustainment operations will be returned to the nearest air hub within 3 days of delivery at the forward operating base. (Request initiated via Service and/or CCMD Pallet and Net Managers.) OWNERSHIP AND FUNDING Although pallets and nets may be authorized to, and in the custody of any Service, DOD, or Federal Agency, they are Air Force property, funded and procured by AFMC. DoDIG-2014-032 I nspec tor Ge ne ral U.S. Department of Defense JA N UA RY 2 7, 2 0 1 4 Defense Logistics Agency Effectively Managed Continental U.S. Mission-Critical Batteries I N T E G R I, EXHIBIT MATERIALS MANAGEMENT REQUIREMENTS FOR CONTRACTED STORAGE PROVIDERS TABLE OF CONTENTS 1. Methods of marrying pallets. Long heavy cargo is loaded first and distributed over the pallets to prevent them from becoming heavy ended. This chapter also discusses types of shoring and how, when, and where it will be used in loading cargo aboard aircraft. %PDF-1.5 Pallets weighing 2,150 pounds or less may be loaded without any problem. PURPOSE. Supplier Responsibilities 1.1. g. Compile and submit reports as requested using inputs from all Services, MAJCOM, and DOD Component organizations. (2) Accountability. TO 35D , System 463L Air Cargo Pallets, HCU-6/E b. Pallets and nets and associated equipment will be used as intermodal devices only. They are secured with 10 centerline ring plug assemblies to the 5K rings in the floor. GENERAL ATTACHMENT V5 AIR FORCE TRANSPORTATION ACCOUNT CODES (TACS) 1. b. Nets. 9. Cellular Telephone: A mobile or portable communication device that can be transported or carried. b. 18-1. PURPOSE. SECTION 12: VETERANS AFFAIRS NATIONAL CEMETERY ADMINISTRATION MEMORIAL PROGRAM CEMETERY MONUMENTS (SUPPLEMENTAL TL RATES) ROUTE ORDER SUBMISSION DoD Business Process Reengineering CONSTRUCTION IN PROGRESS REQUIREMENTS DOCUMENT, AIR FORCE AUDIT AGENCY AIRCRAFT CONFIGURATION MANAGEMENT AUDIT REPORT, Part 111. 39C-7. constrictor cargo system sign The total weight of the HICHS is 825 pounds. NOTE: Always start on the long side of the pallet and work from left to right. The DOD Operational Manager will convene a separate System 463L Pallet and Net Working Group during the off years, as necessary, to discuss and resolve problems identified by the users and to lay the groundwork for the biennial worldwide conference. Risk Planning 1.1. General 1.1. e. Ensure and document, on the revalidation report, that requirements submitted are the minimum essential required to accomplish the mission, by verifying that subordinate activities are adhering to pallet and net requirements determination procedures. 5. Do not ship or transfer unserviceable pallets without a proper condition tag. (3) Determining the area of contact using shoring. Small Business Process. 6. Sec. BROKER is a licensed transportation broker, Report No. Actions Needed to Manage Cash Balances to Required Levels, Software Change Management for Engineering Systems, IUP PURCHASING CARD PROGRAM PROCEDURAL GUIDELINES, UNITED STATES GOVERNMENT. Cardholder Record Keeping and Monthly Reporting Requirements, Department of Defense DIRECTIVE NUMBER 5400.11 October 29, 2014 DCMO SUBJECT: DoD Privacy Program References: See Enclosure 1 1. 39C-9. Sec. (d) Circular barrel with rim. Distribute new production and depot-repaired pallets in coordination with IM, MAJCOM, and DOD Component pallet and net managers. The spacers keep the pallets in line and properly spaced so that they will lock into the rail system of the aircraft (Figure 18-9). Sec. (2) Ramp section. Distributing this weight evenly and over a greater area allows a load of higher-than-normal weight concentration to be carried. Procedure for Netting Pallets. Approve or disapprove requests for permanent modifications to System 463L pallets for specialized transportation purposes b. There are two ramp extension roller assemblies and two ramp extension support assemblies. Product Assurance. Step 5. PURPOSE CHAPTER 604 INTERMODAL CONTAINER INSPECTION, REINSPECTION, MAINTENANCE, AND REPAIR This chapter assigns responsibilities, establishes guidance, and provides procedures for inspection, reinspection, A. 2. SECURING CARGO TO THE PALLET. }. Pallets are repairable at the unit or depot level. 50 inches + 2 inches x 40 inches + 2 inches = 52 x 42 = 2,184 square inches of contact. 39C-11. This regulation prescribes uniform responsibilities, procedures, and guidelines governing, DEPARTMENT OF THE NAVY OFFICE OF THE CHIEF OF NAVAL OPERATIONS 2000 NAVY PENTAGON WASHINGTON, DC 20350-2000 OPNAVINST 4440.26A N4 OPNAV INSTRUCTION 4440.26A From: Chief of Naval Operations Subj: OPERATING, Army Regulation 59 3 Air Transportation Movement of Cargo by Scheduled Military Air Transportation Headquarters Department of the Army Washington, DC 28 June 2013 UNCLASSIFIED SUMMARY of CHANGE AR 59 3. b. Fold them, and then secure the three nets together. Continue hooking ring 22 to ring 27, ring 23 to ring 28, ring 24 to ring 29, and ring 25 to ring 30. <>>> The weight of the object, divided by the length times the width, equals psi. INTRODUCTION. However, to secure cargo to pallets, units must procure and control their own pallet couplers, plastic coverings, tie-down equipment (less nets), and dunnage and/or shoring. The primary, GC GUIDANCE ON INHERENTLY GOVERNMENTAL FUNCTIONS Federal law prohibits contractors from performing inherently governmental functions. This will damage the bottom skin of the pallet. Notify the DOD Operational Manager and IM of System 463L pallet field repair contracts initiated. (b) If the load consists of only pallets, each weighing more than 2,150 pounds, the pallets MUST be spaced longitudinally. (3) Use 463L nets for loose or light items such as small boxes. The weight divided by one-half the base of the triangle, times the height. REMARKS UNIT OF ISSUE QUANTITY REMOVED FROM INSPECTOR S NAME OR STAMP AND DATE DD Form , OCT 66 Figure DD Form , Unserviceable (Reparable) Tag-Materiel VI-608-7, 8 Table Types and Sizes of System 463L Pallets/Nets and Associated Equipment Nomenclature NSN Size/Capacity Pallet, Cargo, Aircraft, HCU-6/E CT 88 X 108 X 2.25 in 10,000 lb capacity 1 Net, Cargo, Tiedown Pallet, Top, HCU-15/C CT 88 X 108 in 10,000 lb capacity 1 Net, Cargo, Tiedown Pallet, Side HCU-7/E (two pieces per top net) CT 88 X 108 in 10,000 lb capacity 1 Coupler, Pallet, C-141/C-130/C CT 2 in 1 Coupler, Pallet, KC-10/DC CT 1 in 1 Strap, Nylon, Tiedown, CGU-1/B ,000 lb capacity 2 Cover, Cargo, Pallet Unit of Issue Roll (10 count) 3 Strap, Webbing, Tiedown ,000 lb capacity 3 Chain, Tiedown, CGU-4E ,000 lb capacity 2 Adjuster, Chain, CGU-3E ,000 lb capacity 2 Chain, Tiedown, MB ,000 lb capacity 2 Adjuster, Chain, MB ,000 lb capacity 2 Tie Down Device, MB , 000 lb. stream Guidance. D EP ART M EN T OF T HE N AVY O FFI CE O F THE SEC RET A RY 100 0 NA VY PE NT A GO N W AS HI NGTO N DC 20 350-1000 SECNAVINST 4440.33 DASN (A&LM) SECNAV INSTRUCTION 4440.33 From: Secretary of the Navy, CLOVER MACHINE AND MFG. 39C-10. General. Intra- or inter-theatre surface (ground or sea) transportation of cargo-loaded System 463L pallets and nets is restricted. One of the key items is the master pallet (463L pallet), which then turned sideways fits on the rollers of the C-130 and C-141 aircraft, and when turned lengthwise, fits on the bed of a truck. Step 14. Request an immediate baseline inventory of pallet and net assets (compilation of the most recent reports maintained at the unit level) upon notification of an impending conflict or contingency situation. The following standard will apply to all System 463L asset taskings/(re) distribution orders: Managers will reply to the tasking within 24 hours (Monday to Thursday) or 72 hours (Friday to Sunday). Private Ordering. The rails are fitted with detents (rail locks) to lock the pallet in place. GFP and CAP Basics Webinar Script Amber Barber 30 April 2010. This instruction: A. TO 13C2-1-1, Cleaning, Repair and Test Instructions for Cargo Tie-Down Equipment, provides cleaning and maintenance instructions for tie-down equipment. Upon initial inspection of nets that have been in storage for any length of time, if the presence of mold is identified, immediately stop inspection and contact the HQ AMC/A4TR for disposition instructions. HQ AMC/A4TR will coordinate with the WR-ALC/WNZDA Program Manager for final disposition instructions. Scope 1.3. h. Use care when loading cargo using MHE, especially when using forklifts with bare tines. Only 463L pallets and nets will be provided by AMC. Report No. The rails also have indents (notches) which can accept rail locks when the pallet is put on an aircraft (Figure 18-1). f. Build the load in a square or pyramid shape (Figure 18-3) to make the load stable and easier to handle. Provide for control, expeditious download, and return of System 463L pallets, nets, and tiedown equipment entering the theater c. Manage air pallet and net inventories, ensure System 463L equipment is returned to the DTS within 3 days of equipment being delivered to the final destination, and report damaged and lost equipment IAW this regulation d. Ensure excess System 463L assets are cleaned and shipped IAW with technical orders (TOs) and directives. B. 2. (2) Securing the pallets together. Headquarters Department of the Army Washington, DC 25 February 2014 UNCLASSIFIED, Mississippi Institutions of Higher Learning IHL Executive Office. 8 Dated Jan., 2016 Page 1 ECAR Part 111 TABLE OF CONTENTS Ministry of Civil Aviation ITEM SUBPART, ARKANSAS TECH UNIVERSITY INVENTORY CONTROL MANUAL SEPTEMBER 2005 PROPERTY MANAGEMENT OFFICE 204 BRYAN EXT. a. Unit CDRs will determine the repair capability for units under their cognizance IAW with Service, Component, or Agency guidance.